登录    |    注册

您好,欢迎来到中国测试科技资讯平台!

首页> 《中国测试》期刊 >本期导读>猪股骨常应变率动态压缩试验方法研究

猪股骨常应变率动态压缩试验方法研究

152    2019-12-30

免费

全文售价

作者:曾煊1, 蒋成约1, 赵辉2, 廖志康2

作者单位:1. 重庆理工大学车辆工程学院, 重庆 400054;
2. 陆军军医大学大坪医院, 重庆 400042


关键词:应变率;材料力学性能;皮质骨;脉冲整形


摘要:

准确的骨骼材料响应对于模拟交通事故、战争和跌落中的人体损伤机制作用重大,波音网上赌场:但上述工况所对应的皮质骨动态力学响应还没有在常应变率条件下被规范测量。为在动态压缩试验中实现和维持不同的恒定应变率,建立针对皮质骨的重复性良好的霍普金森杆动态材料测试方法,并测试大应变率范围内的骨骼材料力学参数。首先测试纯铝整形器尺寸和子弹撞击入射杆速度对入射脉冲形状的改变效果,并在此基础上不断改变入射脉冲形状直至满足常应变率条件,随后对32个加工规则的猪股骨中轴皮质骨试样按照应变率范围进行分组测量。当入射波平台部分斜率与透射波上升沿斜率相等时,试样以常应变率变形,此时常应变率产生的变形超过总应变量的70%。猪股骨皮质骨在200~1 500 s-1应变率间极限应力和极限应变增大(分别为10.2%与25.0%),弹性模量减小(7%)。结果表明,相对于杆材料更软的塑性金属作为整形器能使骨骼在需要的应变率范围内保持应变率恒定,且重复性良好,适宜进一步用于人骨测试。


Dynamic compressive testing method of pig femoral cortical bone
ZENG Xuan1, JIANG Chengyue1, ZHAO Hui2, LIAO Zhikang2
1. School of Vehicle Engineering, Chongqing University of Technology, Chongqing 400054, China;
2. Daping Hospital of Army Medical University, PLA, Chongqing 400042, China
Abstract: Accurate skeletal material response plays an important role for simulating the mechanism of human injury among traffic accidents, wars, and falls, but the dynamic mechanical response of cortical bone corresponding among such load-cases has not been measured under constant strain rate conditions. The present study, thus, aims to achieve and sustain different constant strain rates in dynamic compression, establish a repeatable testing method and reveal the material properties of cortical bone at a wide strain rate range. Effect of the size of aluminum pulse shaper and velocity of the striker on the incent pulse was firstly tested, based on which the incent pulse was adjusted to satisfy the constant strain rate condition. Then, 32 regular machined cortical bone harvested at mid-shaft of pig femurs were divided into 3 groups according to the target strain rate ranges and tested at constant strain rates. As results, constant strain rates condition were only achieved when the slope of incent pulse equals to that of transmit pulse and caused more than 70% of specimen strain. By ncreasing the strain rate from 200 s−1 to 1 500 s−1, the average ultimate strain was increased by 25.0%, ultimate stress was increased by 10.2%, while Young's modulus was decreased by 7.0%. The testing method established by present work based on plastic deformation of relatively softer metal can be easily repeated and suitable for the following test of human cortical bone.
Keywords: strain rate;mechanical property of material;cortical bone;pulse shaping
2019, 45(12):36-42  收稿日期: 2019-03-06;收到修改稿日期: 2019-05-20
基金项目: 国家重点研发计划(2016YFC0800702)
作者简介: 曾煊(1993-),男,四川汶川县人,硕士,研究方向为汽车安全与人体损伤
参考文献
[1] BEKKER A, CLOETE T J, CHINSAMY-TURAN A, et al. Constant strain rate compression of bovine cortical bone on the Split-Hopkinson Pressure Bar[J]. Materials Science & Engineering:C, 2015, 46:443-449
[2] PROT M, CLOETE T J, SALETTI D, et al. The behavior of cancellous bone from quasi-static to dynamic strain rates with emphasis on the intermediate regime[J]. Journal of Biomechanics, 2016, 49(7):1050-1057
[3] CLOETE T J, PAUL G, ISMAIL E B. A preliminary investigation of the dynamic viscoelastic relaxation of bovine cortical bone[C]//The European Physical Journal Conferences, 2015.
[4] CLOETE T J, PAUL G, ISMAIL E B. Hopkinson bar techniques for the intermediate strain rate testing of bovine cortical bone[J]. Philosophical Transactions of the Royal Society. Mathematical, Physical, and Engineering Sciences, 2014, 372(2015):20130210.1-20130210.13
[5] TÜFEKCI K, KAYACAN R, KURBANOĞLU C. Effects of gamma radiation sterilization and strain rate on compressive behavior of equine cortical bone[J]. Journal of the Mechanical Behavior of Biomedical Materials, 2014, 34:231-242
[6] 陈庚. 霍普金森杆波形整形技术研究[D]. 哈尔滨:哈尔滨工程大学, 2015.
[7] 李昕, 陈利, 张庆明, 等. 猪下肢骨骼的冲击压缩试验研究[J]. 中国测试, 2016, 42(10):63-70
[8] FUNG Y C, SKALAK R. Biomechanics:Mechanical properties of living tissues[M]. New York:Springer-Verlag, 1981.
[9] SANBORN B, GUNNARSSON C A, FOSTER M, et al. Quantitative visualization of human cortical bone mechanical response:studies on the anisotropic compressive response and fracture behavior as a function of loading rate[J]. Experimental Mechanics, 2016, 56(1):81-95
[10] WEERASOORIYA T, SANBORN B, GUNNARSSON C A, et al. Orientation dependent compressive response of human femoral cortical bone as a function of strain rate[J]. Journal of Dynamic Behavior of Materials, 2016, 2(1):74-90

姚记赌场 太阳城BBIN电子 申博手机网页版网址 菲律宾太阳城申博娱乐开户 澳门太阳城真人赌场官网
外围庄开户 澳门上葡京真人赌场官方 葡京网现金 皇马ab视讯 太阳城娱乐现金网
太阳城投注 淘金盈真人赌场视讯 澳门老葡京注册网址 申博亚洲官方网 菲律宾申博电子游戏网址
菲律宾申博真人真钱游戏 威尼斯人真人赌钱app 威尼斯人现金网站 申博138注册开户 网络红人斗地